The effective, stable and low cost anodic catalyst or electrode for OER is still a big challenge for water electrolysis in acid condition. Many efforts were devoted to develop suitable supports for depositing Ir and Ru metal or oxides to obtain an enhanced activity or stability for OER.

In this work, self-doped TiO₂ nanotube arrays (sTNTA) which has a higher electrical conductivity than TNTA was chosen as the support, it was fabricated by a simple electrochemical reduction of TNTA in neutral electrolyte. Then IrO₂ nano particles were deposited on it by electrochemical pulse deposition method to form an OER electrode. The cyclic voltammetric behavior, electrical conductivity and micro structure of sTNTA prepared under different reduction potential were characterized to obtain an optimal performance for depositing IrO₂, the OER activity and stability of new electrode were also determined. The obtained sTNTA shows an increased current in CV test than TNTA, which is due to the increased carrier density. As the reduction potential move to more negative level (from -1.5V to -1.9V vs. Ag/AgCl), the carrier density was found increased for 3 order of magnitudes, and XPS characterization confirm the existence of Ti³⁺ which formed in electrochemical reduction process, and sTNTA prepared under -1.9V shows the best electrochemical performance. After depositing IrO₂, IrO₂/sTNTA exhibited higher OER activity than IrO₂/TNTA, according to the CV and EIS test, this can be ascribed to the enhanced electrical conductivity of support, which results in more active sites and lower charge transfer resistance of the electrode. The OER stability of IrO₂/sTNTA was tested under constant current of 5mA/cm², IrO₂/TNTA and IrO₂/Ti which prepared by electrochemical deposition on Ti foil were also tested for comparison. A higher stability of IrO₂/sTNTA electrode was observed than the other two electrodes, and this may be due to the interaction between the IrO₂ and sTNTA. XPS studies show a clear peak shift of Ir4f in IrO₂/sTNTA, indicating a possible lower valence of Iridium, and such lower oxidation state of Iridium may be response for the enhanced OER stability.

In summary, our studies have demonstrated the possibility of self-doped TNTA as a potential anodic support for OER. Comparing with the TNTA, the high electrical conductivity of sTNTA facilitate the charge transfer rate and thus improve the OER activity. Additionally, a higher OER stability was observed for IrO₂/sTNTA electrode, and this may be due to possible catalyst-support interactions between IrO₂ and self-doped TNTA.